Date: Fri, 10 Dec 2004 05:05:35 -0600
Reply-To: John Rodgers <inua@CHARTER.NET>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: John Rodgers <inua@CHARTER.NET>
Subject: Re: refilling tranny fluid
In-Reply-To: <000001c4de6a$c3318a80$4362480c@home>
Content-Type: text/plain; charset=ISO-8859-1; format=flowed
AMEN!!!
What Karl has said here can't be emphasized enough.
Regards,
John Rodgers
88 GL Driver
Karl Wolz wrote:
>Sounds like a lot of extra work for little gain, unless you're planning
>on replacing the gear oil anyway. The tranny is to be filled to within
>5/8" of the fill hole's lower lip. This can easily be checked by using
>an allen-type wrench as a dipstick.
>
>However, the unpardonable sin you're committed here is to tell someone
>to remove the drain plug first. Always be absolutely certain that you
>can remove the fill plug before messing around with the drain plug. If
>the fill plug happens to be seized, the only way to refill the tranny
>will be to remove said tranny!
>
>Karl
>
>
>
>>-----Original Message-----
>>From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On
>>
>>
>Behalf Of
>
>
>>Warren Lail
>>Sent: Thursday, December 09, 2004 7:27 PM
>>To: vanagon@GERRY.VANAGON.COM
>>Subject: Re: refilling tranny fluid
>>
>>To be absolutely sure you have enough tranny oil, I suggest that you
>>
>>
>drain the
>
>
>>tranny by removing the plug (17mm hex)
>>near the engine. Let it drain thoroughly and then replace the plug.
>>
>>
>Then, remove
>
>
>>the refill plug, also a 17 mm hex)
>>just above where the shift linkage attaches to the tranny (you may
>>
>>
>want to make
>
>
>>sure you can get this one off before
>>you drain the tranny!). Then go to O'Reilly's or some other FLAPS and
>>
>>
>get yourself
>
>
>>a small pump made just for this
>>job (about $5). If you have an 091 tranny, pour exactly 3.2 quarts of
>>
>>
>gear oil into a
>
>
>>one gallon jug, attach the hand pump,
>>and stick the hose into the fill hole. Pump away. If you have an
>>
>>
>091/1, I think you
>
>
>>will need about 3.7 quarts. Check
>>Bentley to be sure.
>>
>>Ole Bill Bones is going to get a second newly rebuilt tranny put back
>>
>>
>in 'hisself
>
>
>>tomorrow, but since it is already out
>>of the bus, it is way easier to fill the tranny before you install it,
>>
>>
>and this is exactly
>
>
>>what I intend to do.
>>
>>Warren Lail
>>88 Westy "Billy Bones"
>>
>>"The voices stopped at once, all but Dr. Livesey's; he went on as
>>
>>
>before speaking
>
>
>>clear and kind and drawing briskly
>>at his pipe between every word or two. The captain glared at him for
>>
>>
>a while,
>
>
>>flapped his hand again, glared still harder,
>>and at last broke out with a villainous, low oath, 'Silence, there,
>>
>>
>between decks!'"
>
>
>
>
| 
